Does anyone encounter this problem?

[nitezpeed]

My engine oil is flooding my air box. It seem like it keep pumping oil into the air box. I try install oil catch tank but it still flood it and oil been spill from there. I try install better piston ring but still has the same problem occur. How? Does anyone encounter this problem? Pls help.lease:

 

[KYT]

I'm not an expert, but I don't think the piston rings would have anything to do with that.
If the rings were bad, you'd be burning oil not blowing it in the airbox
I bet its coming in through one of the vacuum lines

 

[nitezpeed]

Thru the vacuum line? please explain more as in detail. Really thanks.

 

[BA BUSA]

If you put too much oil in the engine this can happen. Did you over fill it ???

 

[KYT]

If you put too much oil in the engine this can happen. Did you over fill it ???

would to the FULL line while its running, and on the side stand be too full?

 

[nitezpeed]

I pour the correct amount as in manuals. Its not on the side stand either..
Really headache.???

 

[KOTH]

Just to be clear here are the fill levels. When you say correct amout are you following this table? Just want to make sure you eliminate this as a cause.

 

[BA BUSA]

I pour the correct amount as in manuals. Its not on the side stand either..
Really headache.???

Engine running or engine off when you fill it ???

 

[nitezpeed]

Engine is off.

 

[djsin]

try draining all the oil....then put some sand in there

 

[djsin]

btw dont do what i said above

 

[KYT]

try draining all the oil....then put some sand in there

Sugar is sweeter
Make a nice pastry glaze

 

[Mythos]

It's common to have oil get into the airbox of a ZX-14. Not enough to actually cause an oil consumption problem, I don't think but I saw oil in my airbox. There is a tube that drains any kind of liquid from the airbox on a 14. I would imagine the busa has a similar drain tube.

I really am getting a busa (this week). Honest. Sorry all I have to post is 14 info but I hope it helps.

 

[dadofthree]

Hope you got her taken care of brother....

 

[TruWrecks]

Do you know where it is entering the airbox? What line or vent?

 

[Cookie]

It's blow by coming up through the crankcase vent line. How much are we talking about in the box?

 

[Acehole]

It's blow by coming up through the crankcase vent line. How much are we talking about in the box?

Blow by..i agree. Common for bikes to vent the crankcase thru the air filter. I would change your oil and run it 50 miles or so and then change oil again.

 

[nitezpeed]

Yesh bro. It from the crankcase vent line into the air box. I have block off the connection to the air box and divert to a oil catch tank with a filter for the exit. But now the oil is getting so much that it also flood my oil catch tank. Every riding trip the engine oil is getting lesser and lesser. I have to top up daily due to the loss. Quite a headache. Haiz

 

[OB_Boss]

Make sure you air intakes are not blocked in any way ............. will make motor draw from next available source ............... which will be crank case vent. But on second read if you have re directed hose to catch tank won't be your problem............. sounds like crankcase is pressurising for some reason
Bad compression rings will do it ? As oil control rings will still control oil but still let compression into crankcase

 

[GPW]

Oil should not be checked with bike running........sounds like an overfill issue..or you are getting blow-by which I doubt. The hayabusa takes 4 US quarts nothing more.